Ford Mustang (1999-2004) Service Manual: Component Tests

Grid Wire Test

1. Using a bright lamp inside the vehicle, inspect the wire grid from the exterior. A broken grid wire will appear as a brown spot.

2. Run the engine at idle. Set the rear window defrost switch to ON. The indicator light should come on.

3. Working from the interior of the vehicle with a voltmeter, contact the broad red-brown stripes of the rear glass window positive lead to battery side and negative lead to ground side. The meter should read 10-13 volts. A lower voltage reading indicates a loose ground connection.

4. Contact a good ground point with the negative lead of the meter. The voltage reading should not differ.

5. With the negative lead of the meter grounded, touch each grid line of the heated rear window glass at its midpoint with the positive lead. A reading of approximately 6 volts indicates that the line is good. A reading of zero volts indicates that the line is broken between the midpoint and the B+ side of the grid line. A reading of 12 volts indicates that the circuit is broken between the midpoint of the grid line and ground.

    Inspection and Verification
    1. Verify the customer concern by operating the system. 2. Visually inspect for obvious signs of mechanical or electrical damage. Visual Inspection Chart Mechanical Electrical P ...

    Heated Window Grid Wire Repair
    Material Item Specification Dark Walnut Metallic Acrylic Lacquer Touch-up Paint ALBZ-19500-5858A or equivalent ESR-M2-P100- C Rear Window Defroster Repair D8AZ-19562-AA ...

    Other materials:

    Floor mats
    WARNING: Always use floor mats that are designed to fit the footwell of your vehicle. Only use floor mats that leave the pedal area unobstructed. Only use floor mats that are firmly secured to retention posts so that they cannot slip out of position and inter ...

    Inspection and Verification
    WARNING: Batteries contain sulfuric acid. Avoid contact with skin, eyes, or clothing. Also, shield your eyes when working near batteries to protect against possible splashing of the acid solution. In case of acid contact with skin or eyes, flush ...

    Module - Daytime Running Lamps (DRL)
    Removal 1. CAUTION: Electronic modules are sensitive to static electrical charges. If exposed to these charges, damage can result. Disconnect the battery ground cable. 2. Remove the daytime running lamps (DRL) module and bracket assembly (15A270). ...