Ford Mustang (1999-2004) Service Manual: Removal

CAUTION: Electronic modules are sensitive to static electrical charges. If exposed to these charges, damage may result.

1. Remove the driver air bag module. For additional information, refer to Section.

2. Remove the passenger air bag module. For additional information, refer to Sectio.

3. Remove the LH front wheel and tire assembly. For additional information, refer to Section.

4. Position the LH fender splash shield away from the dash panel.

1. Remove the pin-type retainers.

2. Remove the screws.

3. Position the LH fender splash shield away from the dash panel.

Instrument Panel (Removal and Installation)

5. Disconnect the bulkhead electrical connector from inside the fender opening.

1. Loosen the bolt.

2. Disconnect the bulkhead electrical connector.

Instrument Panel (Removal and Installation)

6. Release the bulkhead electrical connector from the dash panel.

Instrument Panel (Removal and Installation)

7. Install the LH front wheel and tire assembly. For additional information, refer to Section.

8. Remove the floor console. For additional information, refer to Floor Console in this section.

9. Remove the upper RH instrument panel support bolt.

Instrument Panel (Removal and Installation)

10. Disconnect the antenna in-line connector.

Instrument Panel (Removal and Installation)

11. Disconnect the climate control vacuum harness connector.

Instrument Panel (Removal and Installation)

12. Close the glove compartment.

13. Remove the LH and RH scuff plates.

Instrument Panel (Removal and Installation)

14. Remove the LH and RH A-pillar lower trim panels.

1. Remove the pin-type retainers.

2. Remove the A-pillar lower trim panels.

Instrument Panel (Removal and Installation)

15. Remove the LH and RH windshield side garnish mouldings.

  • If equipped with a convertible top, remove the pin-type retainers.

Instrument Panel (Removal and Installation)

16. Position the LH and RH door weatherstrips aside.

17. Disconnect the RH main wiring harness electrical connectors.

Instrument Panel (Removal and Installation)

18. Disconnect the climate control wiring harness connector.

Instrument Panel (Removal and Installation)

19. Remove the instrument panel steering column cover.

1. Remove the screws.

2. Remove the instrument panel steering column cover.

Instrument Panel (Removal and Installation)

20. Remove the instrument panel reinforcement.

1. Remove the screws.

2. Remove the instrument panel reinforcement.

Instrument Panel (Removal and Installation)

21. Separate the intermediate shaft from the steering column shaft.

1. Remove the pinch bolt.

2. Separate the intermediate shaft from the steering column shaft.

Instrument Panel (Removal and Installation)

22. NOTE: The corner of the carpet may have to be pulled back slightly to carry out this step.

Disconnect the LH main wiring harness electrical connectors.

Instrument Panel (Removal and Installation)

23. Disconnect the generic electronic module (GEM) electrical connectors.

Instrument Panel (Removal and Installation)

24. Disconnect the electronic crash sensor (ECS) module electrical connector.

1. Release the locking tab.

2. Disconnect the ECS module electrical connector.

Instrument Panel (Removal and Installation)

25. If equipped, disconnect the shift interlock assembly from the selector lever.

1. Remove the screw.

2. Remove the R-clip.

3. Disconnect the shift interlock cable.

4. Disconnect the shift interlock assembly from the selector lever.

Instrument Panel (Removal and Installation)

26. Remove the audio unit. For additional information, refer to Section.

27. If equipped, disconnect the shifter assembly electrical connector.

Instrument Panel (Removal and Installation)

28. NOTE: This step is being carried out through the audio unit opening.

NOTE: Rotate the temperature control switch to the cool position.

Release the temperature control cable from the blend door.

Instrument Panel (Removal and Installation)

29. Remove the four center instrument panel support bolts.

Instrument Panel (Removal and Installation)

30. Remove the LH instrument panel support bolt and nut.

Instrument Panel (Removal and Installation)

31. Remove the RH instrument panel support bolt.

Instrument Panel (Removal and Installation)

32. Remove the instrument panel defroster grille.

Instrument Panel (Removal and Installation)

33. Remove upper instrument panel support bolts.

Instrument Panel (Removal and Installation)

34. NOTE: Two technicians are necessary to carry out this step.

Remove the instrument panel.

    Installation
    CAUTION: Electronic modules are sensitive to static electrical charges. If exposed to these charges, damage may result. 1. NOTE: Two technicians are necessary to carry out this step. Install ...

    Other materials:

    Synchronizers
    Disassembly and Assembly NOTE: This procedure applies to all synchronizer assemblies. 1. NOTE: Synchronizer components are not interchangeable. During disassembly, mark each individual synchronizer for assembly. Synchronizer hubs and sleeves are a selected a ...

    Horn (Diagnosis and Testing)
    Refer to Wiring Diagrams Cell 44 , Horns/Cigar Lighter for schematic and connector information. Special Tool(s) 73 Digital Multimeter or equivalent 105-R0051 Inspection and Verification 1. Verify the customer concern by operating the h ...

    Axle Housing
    Special Tool(s) Plug Set, Differential 205-294 (T89P-4850-B) Protector, Differential Seal (Pair) 205-461 Remover, Halfshaft 205-475 Remover, Steering Arm 211-003 (T64P-3590-F) ...