Ford Mustang (1999-2004) Service Manual: Removal

1. Raise and support the vehicle.

2. Remove the wheel and tire assembly.

3. WARNING: Brake fluid contains polyglycol ethers and polyglycols. Avoid contact with eyes. Wash hands thoroughly after handling. If brake fluid contacts eyes, flush eyes with running water for 15 minutes, get medical attention if irritation persists. If taken internally, drink water and induce vomiting. Get medical attention immediately.

CAUTION: Brake fluid is harmful to painted and plastic surfaces. If brake fluid is spilled onto a painted or plastic surface, wash it with water immediately.

Disconnect the front brake hose (2078).

1. Remove the front brake flow bolt.

2. Disconnect the front brake hose.

3. Remove and discard the copper washers. Plug the front brake hose.

Caliper

4. Remove the caliper bolts.

1. Hold the guide pins stationary.

2. Remove the caliper bolts.

Caliper

5. Lift the caliper off the anchor plate (2B292).

Caliper

6. Inspect the disc brake caliper.

  • If leaks or damaged boots are found, disassembly is required. For additional information, refer to Caliper in this section.

Caliper

    Caliper
    ...

    Installation
    1. Make sure the anti-rattle spring is correctly positioned in the caliper. 2. CAUTION: Make sure guide pin boots are correctly seated or damage to guide pins can occur. Install the disc brake c ...

    Other materials:

    Component Tests
    Battery-Load Test 1. With the engine running, turn the A/C on, the blower motor on high speed and the headlamps on high beam. 2. Increase the engine speed to approximately 2,000 rpm. The voltage should increase a minimum of 0.5 volt above the ba ...

    Navigation system
    Your navigation system allows you to set a destination by using your touchscreen or voice commands. The navigation system contains map coverage for the United States, Puerto Rico and U.S. Virgin Islands, Canada and Mexico. Disclaimer A disclaimer appears onc ...

    Tire care
    Information About Uniform Tire Quality Grading Tire Quality Grades apply to new pneumatic passenger car tires. The Tire Quality Grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: • Treadw ...