Ford Mustang (1999-2004) Service Manual: Spark Plug Wire
Special Tool(s)
Remover, Spark Plug Wire 303-106 (T74P-6666A) |
Material
Item | Specification |
Silicone Brake Caliper Grease and Dielectric Compound D7AZ-19A331-A or equivalent | ESE-M1C171- A |
Removal and Installation
CAUTION: It is important to twist the spark plug wire boots while pulling upward to avoid possible damage to the spark plug wire.
CAUTION: Spark plug wires must be connected to the correct ignition coil terminal. Mark spark plug wire (12286) locations before removing them.
1. Using the special tool, remove the spark plug wire from the spark plug using a twisting motion.
2. Twist while pulling upward to disconnect the spark plug wires from the ignition coil (12029).
3. CAUTION: Be sure to orient the spark plug boots so the spark plug wires do not contact the exhaust manifold.
NOTE: Apply silicone brake caliper grease and dielectric compound to the inside of spark plug and ignition coil boots of the spark plug wire.
To install, reverse the removal procedure.
Ignition Coil
Material Item Specification Silicone Brake Caliper Grease and Dielectric Compound D7AZ-19A331-A or equivalent ESE-M1C171- A Removal and Installation 1. Disconnect the battery ...Spark Plugs
Special Tool(s) Remover, Spark Plug Wire 303-106 (T74P-6666A) Material Item Specification Silicone Brake Caliper Grease and Dielectric Compound D7AZ-19A331-A or equiva ...Other materials:
Removal
1. Disconnect the battery ground cable. For additional information, refer
to Section.
2. Remove the engine air cleaner outlet pipe. For additional information,
refer to Section.
3. Disconnect the vacuum hose and the idle air control (IAC) valve
elect ...
Battery (Removal and Installation)
Removal and Installation
WARNING: Batteries normally produce explosive gases which can
cause personal injury.
Therefore, do not allow flames, sparks or lighted substances to come
near the battery. When
charging or working near a battery, always sh ...
Heater Core Backflushing
Special Tool(s)
Flush Kit
164-R3658 or equivalent
Drain Kit
164-R3662 or equivalent
Material
Item
Specification
Motorcraft Premium Cooling
System Flush
VC-1 or equivalent
ESR-M14P7-A
Motorcraft Premium ...