Ford Mustang (1999-2004) Service Manual: Starter Motor - 4.6L

Removal

WARNING: When servicing starter motor (11002) or carrying out other underhood work in the vicinity of the starter motor, be aware that the heavy gauge battery input lead at the starter solenoid (11390) is "electrically hot" at all times. A protective cap or boot is provided over this terminal that must be installed after servicing. Be sure to disconnect the battery negative cable before servicing the starter. Failure to follow these instructions can result in personal injury.

WARNING: When working in area of the starter motor, be careful to avoid touching hot exhaust components. Failure to follow these instructions can result in personal injury.

NOTE: When working on the starter system, make sure the anti-theft system is deactivated (if equipped.)

1. Disconnect the battery ground cable. For additional information, refer to Section.

2. Raise and support the vehicle. For additional information, refer to Section.

3. Remove the red starter solenoid safety cap.

4. Remove the starter solenoid nuts and position aside the wires.

Starter Motor - 4.6L

5. NOTE: To ease removal, remove the upper, concealed bolt first.

Remove the three starter motor bolts.

Starter Motor - 4.6L

6. Remove the starter motor.

Installation

1. Position the starter motor to the engine.

2. NOTE: To ease installation, first install the two lower bolts finger tight, then install the upper, concealed bolt. Tighten all three bolts to specification.

Install the three starter motor bolts.

Starter Motor - 4.6L

3. Connect the starter motor solenoid and starter motor cable connections.

Starter Motor - 4.6L

4. Install the red starter solenoid safety cap.

5. Lower the vehicle.

6. Connect the battery ground cable.

 

    Starter Motor - 3.8L
    Removal WARNING: When servicing starter motor (11002) or carrying out other underhood work in the vicinity of the starter motor, be aware that the heavy gauge battery input lead at the starter ...

    Engine Ignition - 3.8L
    General Specifications Torque Specifications ...

    Other materials:

    Accessory Drive - Cobra
    Component Locations -Supercharger Accessory Drive   Component Location -Accessory Drive   ...

    Weld Nut Repair - Missing Weld Nut, Restraints Control Module (RCM)
    WARNING: To avoid accidental deployment and possible personal injury, the backup power supply must be depleted before repairing or replacing any front or side air bag supplemental restraint system (SRS) components and before servicing, replacing, ...

    Removal
    1. Remove the rear defrost connectors if necessary. 2. Remove the nuts retaining the well sling and convertible top tacking strips. 3. Remove the three tacking strips. 4. Mark the top of the convertible top skin around the top of all three tacking s ...