Ford Mustang (1999-2004) Service Manual: Stoplamps
Refer to Wiring Diagrams Cell 90 , Turn/Stop/Hazard Lamps for schematic and connector information.
Special Tool(s)
73III Automotive Meter or equivalent 105-R0057 |
Inspection and Verification
1. Verify the customer concerns.
2. Visually inspect for the following obvious signs of mechanical or electrical damage.
Visual Inspection Chart
Mechanical |
Electrical |
|
|
3. If an obvious cause for an observed or reported concern is found, correct the cause (if possible) before proceeding to the next step.
4. If the concern is not visually evident, determine the symptom and refer to the Symptom Chart.
Symptom Chart
Condition | Possible Sources | Action |
|
|
|
|
|
|
|
|
|
Pinpoint Tests
PINPOINT TEST G: THE STOPLAMPS ARE INOPERATIVE
Test Step | Result / Action to Take |
G1 CHECK CIRCUIT 10 (LG/RD) FOR AN OPEN | Yes GO to G2 . No REPAIR the circuit. TEST the system for normal operation |
|
|
G2 CHECK THE CIRCUIT 810 (RD/LG) FOR AN OPEN | Yes INSTALL a new BPP switch. REFER to Lamp Switch- Brake Pedal Position (BPP) in this section. TEST the system for normal operation. No REPAIR circuit 810 (RD/LG) or 569 (DG) as necessary. TEST the system for normal operation. |
|
PINPOINT TEST H: ONE OR MORE STOPLAMPS ARE INOPERATIVE
Test Step | Result / Action to Take |
H1 CHECK THE VOLTAGE TO THE INOPERATIVE STOPLAMP | Yes REPAIR circuit 1205 (BK). TEST the system for normal operation. No If high mounted stoplamp, REPAIR circuit 569 (DG). TEST the system for normal operation. If rear stoplamp, GO to H2 . |
|
|
H2 CHECK CIRCUIT 9 (LG/OG) OR 5 (OG/LB) FOR AN OPEN | Yes INSTALL a new multifunction switch. REFER to Section . TEST the system for normal operation. No REPAIR the circuit in question. TEST the system for normal operation. |
|
PINPOINT TEST I: THE STOPLAMPS ARE ON CONTINUOUSLY
Test Step | Result / Action to Take |
I1 CHECK THE BRAKE PEDAL POSITION (BPP) SWITCH | Yes GO to I2 . No INSTALL a new BPP switch. REFER to Lamp Switch- Brake Pedal Position (BPP) . TEST the system for normal operation. |
|
|
I2 CHECK THE SPEED CONTROL SYSTEM | Yes GO to I3 . No REFER to Section. |
|
|
I3 CHECK CIRCUIT 511 (LG) FOR SHORT TO POWER | Yes GO to I4 . No REPAIR the circuit. TEST the system for normal operation |
|
|
I4 CHECK CIRCUIT 810 (LG/RD) FOR SHORT TO POWER | Yes GO to I5 . No REPAIR the circuit. TEST the system for normal operation |
|
|
I5 CHECK THE MULTIFUNCTION SWITCH | Yes If the high mounted stoplamp is illuminated, REPAIR circuit 569 (DG) or 511 (LG) as necessary. TEST the system for normal operation. If only the LH stoplamp is illuminated, REPAIR circuit 9 (LG/OG). TEST the system for normal operation. If only the RH stoplamp is illuminated, REPAIR circuit 5 (OG/LB). TEST the system for normal operation. No INSTALL a new multifunction switch. REFER to Section. TEST the system for normal operation |
|
Headlamps
Refer to Wiring Diagrams Cell 85 , Headlamps for schematic and connector information. Special Tool(s) 73III Automotive Meter or equivalent 105-R0057 Inspection and Verification ...Turn Signal and Hazard Lamps
Refer to Wiring Diagrams Cell 90 , Turn/Stop/Hazard Lamps for schematic and connector information. Special Tool(s) 73 III Automotive Meter 105-R0057 or equivalent Inspection and Ver ...Other materials:
Auxiliary Power Points
WARNING: Do not plug optional electrical accessories into the
cigarette lighter socket (if equipped). Improper use of the lighter
can cause damage not covered by your warranty, and can result in fire
or serious injury.
Note: If used when the engine is not runn ...
Troubleshooting
Your SYNC system is easy to use. However, should questions arise, see
the tables below.
Use the website at any time to check your phone’s compatibility,
register your account and set preferences as well as access a
customer representative via an online chat ...
Piston Inspection
Special Tool(s)
Scraper, Piston Ring Groove
303-D033 (D81L-6002-D) or
equivalent
CAUTION: Do not use a caustic cleaning solution or a wire brush to
clean the pistons or
damage can occur.
1. Clean and inspect the (1) ring lands, (2) skirts, ...