Ford Mustang (1999-2004) Service Manual: Washer Pump

Removal

1. Remove the LF wheel and tire. Refer to Section.

2. Position the front portion of the LF inner splash shield aside.

3. WARNING: Windshield washer solution contains methanol, which is poisonous.

Observe all cautions and warnings indicated on label of washer solution container.

NOTE: To prevent spilling windshield washer fluid, drain the windshield washer reservoir before removal.

Remove the washer pump.

1. Disconnect the electrical connector.

2. Disconnect washer hose from the washer pump.

3. Remove the washer pump.

Washer Pump

Installation

1. WARNING: Windshield washer solution contains methanol, which is poisonous.

Observe all cautions and warnings indicated on label of washer solution container.

CAUTION: Do not operate the windshield washer pump prior to filling the windshield reservoir.

To install, reverse the removal procedure.

  • Fill the windshield washer reservoir.
    Motor - Windshield Wiper
    Removal CAUTION: The internal permanent magnets used in the windshield wiper motor are made of a glass-like material. To avoid damaging the magnets, do not strike the motor with a hammer o ...

    Reservoir
    Removal 1. Remove the LF wheel and tire. Refer to Section. 2. Position the front portion of the LF inner splash shield aside. 3. WARNING: Windshield washer solution contains methanol, which is ...

    Other materials:

    Inspection and Verification
    NOTE: Upon installation of a new GEM, the module must be reconfigured. For additional information, refer to Section. 1. The warning lamps are a GEM controlled system; refer to Section. 2. Verify the customer concern by operating the system in questio ...

    Switch - Exterior Rear View Mirror Control
    Removal 1. CAUTION: Use a shop towel or similar material between the tool and the front door trim panel or damage to the front door trim panel may occur. Position the window regulator switch plate aside. 1. Pull at service notch. 2. Lift to release ...

    Driveshaft (Description and Operation)
      NOTE: All driveshaft assemblies are balanced. If undercoating the vehicle, protect the driveshaft to prevent overspray of any undercoating material. The driveshaft has the following features: A tubular shaft used to transfer engine torque from the ...