Ford Mustang (1999-2004) Service Manual: Speakers

Torque Specifications

Torque Specifications

Speakers

NOTE: Premium sound speakers (18808) are labeled with either 6 OHMS or 8 OHMS.

  • The coupe has a four-speaker system, with two door-mounted speakers and two in the package tray panel (46506).
  • On the convertible, the two rear speakers are located behind the quarter trim panel. (31012)
  • The MACH 460 subwoofer system has eight speakers. On the coupe, two are located in each door and four are in the subwoofer assembly. On the convertible, two speakers are in each door and two are mounted in each subwoofer assembly behind the rear quarter trim panels. Both the coupe and convertible subwoofer assemblies are not repairable.
  • The MACH 1000 has all the components of the MACH 460 system plus two additional subwoofers located on each side of the trunk and four additional amplifiers. These subwoofers can be serviced independently.
Cable - Antenna Lead In
Removal 1. Remove the audio unit. Refer to Section. 2. Lower the glove compartment by releasing the stops from the instrument panel. 3. Disconnect the antenna in-line connector. 4. Remove ...

Door Speaker - Upper
Removal and Installation 1. Remove the front door trim panels (239420). For additional information, refer to Section 2. Remove the upper speaker access cover. 3. Remove the upper speaker hous ...

Other materials:

Engine - 4.6L (2V)
General Specifications a - With installation of a new filter. b - Distance front edge of bearing is installed below front face of cylinder block. c - Time necessary for plunger to leak down 1.6 mm of travel with 222 N force and leak down fluid in tap ...

Vacuum Control Motor - Air Damper Door
Removal 1. Remove the instrument panel. For additional information, refer to Section. 2. Disconnect the vacuum hose. 3. Remove the vacuum control motor. 1. Remove the steel clip. 2. Loosen the nuts. Installation 1. To install, reverse the removal proc ...

Inspection and Verification
1. Verify the customer concern by operating the system. 2. Visually inspect for obvious signs of mechanical or electrical damage. Visual Inspection Chart Mechanical Electrical Power window regulator Window run weatherstrip Do ...