Ford Mustang (1999-2004) Service Manual: Evaporative Emission Test Port

Removal and Installation

1. Disconnect the pin-type retainer.

Evaporative Emission Test Port

2. Raise and support the vehicle. For additional information, refer to Section.

3. Remove the RH front wheel. For additional information, refer to Section.

4. Remove the RH front splash shield.

1. Remove the three screws.

2. Remove the five pin-type retainers.

Evaporative Emission Test Port

5. Remove the evaporative emission test port by disconnecting at the EVAP canister purge outlet tube junction.

Evaporative Emission Test Port

6. To install, reverse the removal procedure.

  • Leak test the system. For additional information, refer to Evaporative Emission System Leak Test in this section.
  • Carry out the evaporative emission repair verification drive cycle. For additional information, refer to Evaporative Emission Repair Verification Drive Cycle in this section.

Evaporative Emission Canister Vent Solenoid

Removal and Installation

1. Remove the canister vent solenoid. For additional information, refer to Evaporative Emission Canister in this section.

 

    Fuel Vapor Control Tube Assembly Valve
    Removal and Installation 1. Remove the fuel tank. For additional information, refer to Section. 2. Remove the retainers. 3. NOTE: The fuel vapor vent valve, fuel vapor control valve and the ...

    Electronic Engine Controls
    General Specifications Torque Specifications ...

    Other materials:

    Ignition Lock Cylinder - Functional
    Removal and Installation 1. Disconnect the battery ground cable. For additional information, refer to Section. 2. Remove the ignition switch lock cylinder (11582). 1. Insert the ignition key and turn to the RUN position. 2. Using a 1/8-inch d ...

    Ignition Coil - Coil On Plug
    Removal 1. Disconnect the battery ground cable (14301). For additional information, refer to Section. 2. Remove the air cleaner outlet tube (9B659). For additional information, refer to Section. 3. NOTE: One ignition coil is shown, and the others are ...

    Air Conditioning (A/C) System Recovery, Evacuation and Charging
    Special Tool(s) R-134a A/C Refrigerant Center 176-00002 or equivalent R-134a A/C Refrigerant Center 023-00153 or equivalent R-134a Manifold Gauge Set 176-R032A or equivalent 1.2 CFM Vacuum Pump 023-00162 o ...