Ford Mustang (1999-2004) Service Manual: Removal

NOTE: This procedure applies to both the LH and RH halfshafts.

1. CAUTION: The vehicle must be on level ground and at curb height.

Mark the rear shock absorber relative to the protective sleeve.

  • During installation, raise the suspension to this reference mark before tightening the suspension component fasteners.

Halfshaft

2. Raise and support the vehicle.

3. Remove the rear wheel and tire assembly.

4. Remove and discard the rear axle wheel hub retainer.

Halfshaft

5. Remove the rear brake disc.

6. Remove the rear brake anti-lock sensor and position aside.

Halfshaft

7. Support the suspension lower arm and bushing. This will ease removal of the lower shock absorber mount bolt.

Halfshaft

8. Disconnect the shock absorber at the suspension lower arm and bushing. Discard the nut and the bolt.

Halfshaft

9. Remove and discard the cotter pin and the nut.

Halfshaft

10. Using the special tool, disconnect the tie-rod link at the knuckle.

Halfshaft

11. Disconnect the suspension upper arm and bushing at the knuckle. Discard the nut and the bolt.

Halfshaft

12. Using the special tool, press the outboard CV joint until it is loose in the hub.

Halfshaft

13. CAUTION: Do not over-angulate the outboard CV joint or damage the boot.

While lowering the knuckle, remove the CV joint from the hub.

14. CAUTION: The crown on the tool forks must face away from the axle housing.

Position the special tool correctly between the CV joint and the axle housing so as not to damage the differential seal.

Using the special tool, exert enough pressure to overcome the circlip and separate the CV joint (4K326) from the differential side gear.

Halfshaft

15. CAUTION: Do not damage the differential seal.

Carefully remove the halfshaft (4K138) with both hands.

16. Install the special tool.

Halfshaft

    Halfshaft
    Special Tool(s) Differential Plug 205-294 (T89P-4850-B) Differential Seal Protector 205-461 Front Hub Remover 205-D070 (D93P-1175-B) or Equivalent Halfshaft ...

    Installation
    1. NOTE: This procedure applies to both the LH and RH halfshafts. Install a new driveshaft bearing retainer circlip. 2. Remove the special tool. 3. CAUTION: Differential seal damage will occur if i ...

    Other materials:

    Removal
    1. Disconnect the battery ground cable (14301). 2. Remove the air cleaner outlet tube (9B659). 3. Remove the radiator sight shield (8C291). 4. Remove the coolant recovery reservoir (8A080). 1. Disconnect the hose. 2. Remove the bolts. 3. Remo ...

    Removal
    1. Remove the center instrument panel register. 2. Remove the screws. 3. Disconnect the connectors. 4. Using the special tool, disconnect the temperature control cable from the control head. 5. Remove the nuts and disconnect the vacuum connector. ...

    Diagnostic Instructions - Air Bag Supplemental Restraint System (SRS)
    Special Tool(s) Worldwide Diagnostic System (WDS) 418-F224, New Generation STAR (NGS) Tester 418-F052, or equivalent scan tool The symptom chart can be used to help locate the air bag supplemental restraint system (SRS) concerns if n ...