Ford Mustang (1999-2004) Service Manual: Disassembly

1. Remove the driveshaft (4602). For additional information, refer to Driveshaft in this section.

2. CAUTION: Under no circumstances is the driveshaft assembly to be clamped in the jaws of a vise or similar holding fixture. Denting or localizing fracture can result, causing driveshaft failure during vehicle operation.

Place the driveshaft on a suitable workbench, being careful not to damage the tube.

3. NOTE: If components are not marked and installed correctly, driveline imbalance can occur.

Index-mark the positions of the driveshaft components.

Universal Joint - Single Cardan, Flange Yoke

4. Clamp the U-joint tool in a vise.

Universal Joint - Single Cardan, Flange Yoke

5. Remove all four of the snap rings.

Universal Joint - Single Cardan, Flange Yoke

6. Remove the driveshaft flange yoke.

1. Position the driveshaft flange yoke in the U-joint tool.

2. Press out a bearing cup.

3. Remove the driveshaft flange yoke.

4. Press on the spider to remove the remaining bearing cup.

5. Remove the driveshaft flange yoke.

Universal Joint - Single Cardan, Flange Yoke

7. Remove the spider.

1. Reposition the driveshaft in the U-joint tool.

2. Press out the bearing cup.

3. Rotate the driveshaft.

4. Press on the spider to remove the remaining bearing cup.

5. Remove the spider.

Universal Joint - Single Cardan, Flange Yoke

8. Clean the yoke area at the end of the driveshaft.

    Universal Joint - Single Cardan, Flange Yoke
    Special Tool(s) Installer/Remover, C Frame and Screw 205-086 (T74P-4635-C) ...

    Assembly
    1. NOTE: Universal joint kits are to be installed as complete assemblies only. Do not mix components from other U-joint kits. Install the spider. 1. Start a new bearing cup into the driveshaft yok ...

    Other materials:

    Connecting Rod - Side Clearance
    1. Measure the clearance between the connecting rod and the crankshaft. Verify the measurement is within specification. Refer to the appropriate section in Group for the procedure. If out of specification, install new components as necessary. Refer ...

    Spark Plug - Inspection
    1. Inspect the spark plug for a bridged gap. Check for deposit build-up closing the gap between the electrodes. Deposits are caused by oil or carbon fouling. Clean the spark plug. 2. Check for oil fouling. Check for wet, black deposits on th ...

    Power seats
    WARNING: Never adjust the driver’s seat or seat back when the vehicle is moving. WARNING: Before returning the seat back to its original position, make sure that cargo or any objects are not trapped behind the seat back. The power seat control is located on ...