Ford Mustang (1999-2004) Service Manual: Installation
1. Clean the A/C disc and field coil and pulley mounting surfaces.
2. CAUTION: Do not use air tools. The A/C clutch field coil can be easily damaged.
Install the A/C clutch field coil.
1. Place the A/C clutch field coil on the A/C compressor with the A/C clutch field coil electrical connector correctly positioned.
2. Using the special tools, install the A/C field coil.
3. NOTE: The A/C clutch pulley is a tight fit on the A/C compressor head. It must be correctly aligned during installation.
Install the A/C clutch pulley.
4. Install the pulley snap ring with the bevel side out.
5. Place one nominal thickness A/C clutch hub spacer inside the clutch hub spline opening.
6. Install the A/C clutch.
7. Using the special tool, install the A/C disc and hub assembly retaining bolt.
8. Measure and adjust the clutch air gap by removing or adding A/C clutch hub spacers.
9. Install the A/C compressor. For additional information, refer to Air Conditioning (A/C) Compressor-3.8L or Air Conditioning (A/C) Compressor-4.6L in this section.
Removal
1. Remove the A/C compressor (19703). For additional information, refer to Air Conditioning (A/C) Compressor-3.8L or Air Conditioning (A/C) Compressor-4.6L in this section. 2. Remove the bolt. 1. ...Air Conditioning (A/C) Compressor Shaft Seal
Special Tool(s) Holding Fixture, Compressor Clutch (3.8L vehicles) 412-098 (T94P-19703-AH) Holding Fixture, Compressor Clutch (4.6L vehicles) 412-103 (T95L-19703-AH) ...Other materials:
Roller Followers
Special Tool(s)
Compressor, Valve Spring
303-452 (T93P-6565-AR)
Removal and Installation
1. Remove the LH and RH valve cover. For additional information, refer to
Valve Cover LH and
Valve Cover RH in this section.
2. Position the piston of t ...
Special Operating Condition Requirements
When towing a trailer or using a camper or car-top carrier:
Change engine oil and install a new oil filter every 4,800 km (3,000
miles) or 3 months.
Change transfer case fluid every 96,000 km (60,000 miles).
Change manual transmission fluid as required.
...
Changing a fuse
Fuses
WARNING: Always replace a fuse with one that has the
specified amperage rating. Using a fuse with a higher amperage
rating can cause severe wire damage and could start a fire.
If electrical components in your
vehicle are not working, a fuse may
have blo ...