Ford Mustang Service Manual: Gearshift Lever and Boot

Manual Transmission

The TR3650 five-speed manual transmission features the following:

  • The fifth speed gear functions as an overdrive gear.
  • The forward gears are synchronized and helical cut.
  • The reverse gear operates through a constant-mesh, fully synchronized system.
  • The shift interlock system prevents the engagement of more than one gear.
  • The countershaft is serviced as an assembly.
  • An aluminum main case, extension housing and bell housing.

Transmission Internal Components - Disassembled View

 


 



Transmission Case and Shift Components - Disassembled View


Transmission Case and Shift Components - Disassembled View

 


 


Transmission Identification


Transmission Identification

The transmission identification tag is located under the lower bolt that retains the extension housing to the main case.

The five speed overdrive (TR3650) transmission is available for the Mustang 4.6L (2V).

Transmission Identification

 


 

Bearings - Inspection


    Seal
    Manual Transmission The TR3650 five-speed manual transmission features the following: The fifth speed gear functions as an overdrive gear. The forward gears are synchronized and helical cut. ...

    Output Shaft Speed (OSS) Sensor
    Manual Transmission The TR3650 five-speed manual transmission features the following: The fifth speed gear functions as an overdrive gear. The forward gears are synchronized and helical cut. ...

    Other materials:

    Generator - 4.6L 2V
    Generator - 3.8L Removal and Installation 1. Disconnect the battery (10655). For additional information, refer to Section. 2. Relieve the accessory drive belt (8620) tension and remove the belt from the generator pulley. Leave the belt in place ...

    Steering Wheel
    Adjusting the steering wheel WARNING: Do not adjust the steering wheel when your vehicle is moving. Note: Make sure that you are sitting in the correct position. See Sitting in the Correct Position in the Seats chapter. 1. Unlock the steering column. 2 ...

    Starter Motor - 3.8L
    Starting System (Description and Operation) Starter Motor The starter motor is a 12-volt unit that has the starter solenoid mounted on the drive end housing and functions as follows: The current flows through the solenoid energizing coil until the solenoi ...